Skip to main content

    plumbing troubleshooting

    Install tankless water heater

    Common symptoms: converting to tankless; tankless install planning; replacing tank with tankless; endless hot water upgrade

    Stop and call a pro if:

    • gas-line sizing and pressure
    • Category III stainless or PVC venting and termination clearances
    • condensate acidity (neutralizer required for condensing units)
    • dedicated electrical circuit
    • permit and inspection requirement
    • CO risk on improperly vented gas units

    Step-by-step diagnostic flow

    1. Step 1

      Which scenario best describes your project?

      The scope of a tankless install varies enormously. A whole-home gas conversion is a major job; replacing a small electric point-of-use unit with the same is a screwdriver job.

    2. Step 2

      Is the replacement unit the same voltage and amperage as the old one, fed from an existing dedicated circuit that's already correctly sized for the new unit?

      Read both data plates. If amperage goes up at all, the circuit, breaker, and wire gauge may all need upsizing — that's electrician work.

    3. Step 3

      Is the new unit installing in the same location, with the same water connections and same shutoff valves?

    Possible outcomes

    Hire a licensed plumber — whole-home gas tankless is not a DIY project

    high confidence

    A whole-home gas tankless typically demands 150–200k BTU/hr — 4–5x a gas tank — which usually means upsizing the gas line from the meter to the unit, confirming meter and regulator capacity, installing Category III stainless or PVC venting per the model's spec with strict termination clearances, adding a condensate drain with neutralizer for condensing units, a dedicated 120V circuit, and a sediment trap. Each item has code consequences and CO/fire risk if wrong.

    Safe next steps
    • Get 2–3 quotes from licensed plumbers who install your target brand
    • Ask each quote to spec out: gas-line upsize calc, vent material + termination location, condensate drain + neutralizer, dedicated electrical, water-side isolation valves for descaling, and permit
    • Confirm your gas meter and service can supply the added BTU load — the plumber should check with the utility if marginal
    • Plan for the larger upfront cost vs. a tank; tankless wins on lifetime and capacity, not first-day price
    • Get a water-hardness reading — hard water shortens tankless heat-exchanger life without annual descaling
    What to document for a pro
    • Photos of current heater, gas meter, panel, and proposed install location
    • Distance from gas meter to install location
    • Water hardness if known
    • Peak hot-water demand (simultaneous fixtures)

    Hire a licensed plumber + electrician — whole-home electric tankless is huge electrical load

    high confidence

    Whole-home electric tankless units typically need 80–150A at 240V — often 2–3 dedicated double-pole breakers and very heavy gauge wire. Most existing 200A panels can't accommodate this without a load calc, and many homes need a service upgrade. This is electrician territory before it's plumber territory.

    Safe next steps
    • Have an electrician do a load calculation on your panel — many homes won't support whole-home electric tankless without a service upgrade
    • If the panel supports it, get a plumber + electrician to scope the install jointly
    • Compare lifetime cost vs. heat-pump tank — heat pump often wins on operating cost in mixed climates with major rebates available
    • Pull permits for both plumbing and electrical work
    What to document for a pro
    • Photo of panel with cover off (by an electrician)
    • Current main service amperage
    • Photos of current heater and proposed location
    • Peak simultaneous fixture demand

    Major project — full design work needed before quotes

    high confidence

    Going from electric tank to gas tankless requires a new gas line from the meter, all the venting and condensate infrastructure above, AND removing or repurposing the existing electric circuit. This is a multi-trade project that needs design, not just installation.

    Safe next steps
    • Hire a licensed plumber for a paid site assessment and design
    • Compare against the simpler alternative: stay electric and install a heat-pump water heater (often substantial rebates and no gas-line work)
    • If proceeding with gas: budget for plumber, gas fitter (often the same person), and possibly utility service upgrade
    • Pull all required permits — plumbing, gas, electrical
    What to document for a pro
    • Photos of current install, panel, and proposed location
    • Distance to gas meter
    • Whether you've already had a utility consult

    Hire a licensed plumber — new install needs design

    high confidence

    An install at a new location requires choosing the spot for vent clearances, gas/electrical access, water supply runs, and condensate drainage — these decisions affect performance and code compliance for the life of the unit.

    Safe next steps
    • Hire a licensed plumber for site assessment
    • Decide between gas and electric based on existing utilities and demand
    • Pull permits for plumbing, electrical, and (gas) mechanical / gas
    What to document for a pro
    • Photos of proposed location with measurements
    • Photos of nearby gas line / panel / water supply
    • What fixtures the unit will serve

    Get an electrician to size the circuit, then swap

    medium confidence

    If the new point-of-use unit's electrical spec differs from the old one, the breaker and wire may need upsizing — that's panel work, not a DIY plumbing swap.

    Safe next steps
    • Have an electrician confirm or upgrade the circuit, breaker, and wire gauge for the new unit
    • Once the circuit is correct, re-run this guide for the plumbing swap
    What to document for a pro
    • Old and new unit data plates (voltage, amperage)
    • Photo of the breaker feeding the unit

    DIY swap is reasonable — same spec, same location, electric point-of-use

    medium confidence

    A like-for-like electric point-of-use swap with no electrical, water-routing, or gas changes is a defensible DIY job. Still pull a permit if your jurisdiction requires it.

    Safe next steps
    • Confirm permit requirements with your building department
    • Shut off the breaker at the panel; verify dead at the unit's junction box with a non-contact voltage tester before touching wiring
    • Close the cold-water shutoff feeding the unit; open the downstream tap to relieve pressure and let the unit drain
    • Disconnect water, then electrical; remove old unit
    • Mount new unit per its instructions; reconnect water with new flex connectors and fresh PTFE tape on threaded fittings
    • Reconnect electrical, restore water FIRST, purge air through the downstream tap, then re-energize the breaker
    • Set output temperature no higher than 120°F
    • Watch for leaks and verify operation over the next 24 hours
    What to document for a pro
    • Only if stuck — photos of where you paused
    Diagnostic guidance only. If unsure, stop and call a licensed professional — gas, electrical, and refrigerant work is hazardous to untrained users.

    Pro launch updates

    Get notified when Pro launches, plus a monthly code-change digest. Email only — no account required.